Yandex MC
Alldata online

Alldata online. Is free

DATACENTER ERROR!!! Внимание! Авария в датацентре!!


Subscribe to the telegram channel https://t.me/kolhosniki_en

Place for your advertisement

predsedatel@kolhosniki.ru
Click for start

Diagnosis and repair



The following procedures must be used when verifying customer concerns for E4OD transmission:

1.Required equipment:
-E4OD Transmission Tester 007-00085 or equivalent
-SUPER STAR II Tester 007-0041-A or equivalent

NOTE: The SUPER STAR II Tester 007-0041-A or equivalent must be used on fast mode to properly display the On-Board Diagnostic codes.

-Digital Volt Ohmmeter 007-00001 or equivalent
-Manual Lever Position Sensor Tester D89T-700 10-A or equivalent
-Gear Position Sensor Adjuster T9 1P-700 10-A
-60-Pin Breakout Box 007-00033 or equivalent
-(TP) VRV Gauge Block T92T-7B200-AH

2.Determine customer concerns relative to vehicle usage:
-Hot or cold vehicle operating temperature
-Hot or cold ambient temperatures
-Type of terrain
-Vehicle loaded/unloaded
-City/highway driving

NOTE: Some E4OD transmission conditions may cause engine concerns. An EPC short circuit may cause alternate firing. The torque converter clutch not disengaging will stall the engine.

3.Fluid level and condition.

4.Road test vehicle to verify customer concern.

NOTE: Inspect vehicle for non-Ford approved add-on devices such as:
-Air conditioning
-Generators (alternators)
-Engine turbos
-Cellular telephones
-Cruise controls
-CB radios
-Linear boosters
-Backup alarm signals
-Computers

NOTE: These items, if not installed properly, will affect PCM or transmission function. Pay particular attention to add-on wiring splices in the PCM or transmission wiring harness, abnormal tire size or axle ratio changes.

5.After a road test, with the vehicle warm and before disturbing any connectors, perform the Quick Test using SUPER STAR II Tester 007-0041-A or equivalent.


This project exists mainly due to the display of advertising.

Due to the international situation, making a profit from advertising has become impossible.

If this continues, then the project will either close completely, or become closed and paid.

To support the project, you can Buy a paid subscription


Can be closed in 20